The impact of gravity segregation on multiphase non-Darcy flow in hydraulically fractured gas wells

Date

2008-10-10

Journal Title

Journal ISSN

Volume Title

Publisher

Texas A&M University

Abstract

Multiphase and non-Darcy flow effects in hydraulically fractured gas wells reduce effective fracture conductivity. Typical proppant pack laboratory experiments are oriented in such a way such that phase segregation is not possible, which results in mixed flow. Tidwell and Parker (1996), however, showed that in proppant packs, gravity segregation occurs for simultaneous gas and liquid injection at laboratory scale (1500 cm2). Although the impact of gravity on flow in natural fractures has been described, previous work has not fully described the effect of gravity on multiphase non-Darcy flow in hydraulic fractures. In this work, reservoir simulation modeling was used to determine the extent and impact of gravity segregation in a hydraulic fracture at field scale. I found that by ignoring segregation, effective fracture conductivity can be underestimated by up to a factor of two. An analytical solution was developed for uniform flux of water and gas into the fracture. The solution for pressures and saturations in the fracture agrees well with reservoir simulation. Gravity segregation occurs in moderate-to-high conductivity fractures. Gravity segregation impacts effective fracture conductivity when gas and liquid are being produced at all water-gas ratios modeled above 2 Bbls per MMscf. More realistic, non-uniform-flux models were also run with the hydraulic fracture connected to a gas reservoir producing water. For constant-gas-rate production, differences in pressure drop between segregated cases and mixed flow cases range up to a factor of two. As the pressure gradient in the fracture increases above 1 to 2 psi/ft, the amount of segregation decreases. Segregation is also less for fracture half-length-to-height ratios less than or close to two. When there is less segregation, the difference in effective conductivity between the segregated and mixed flow cases is reduced. I also modeled the water injection and cleanup phases for a typical slickwater fracture treatment both with and without gravity effects and found that for cases with segregation, effective fracture conductivity is significantly higher than the conductivity when mixed flow occurs. Gravity segregation is commonly ignored in design and analysis of hydraulically fractured gas wells. This work shows that segregation is an important physical process and it affects effective fracture conductivity significantly. Hydraulic fracture treatments can be designed more effectively if effective fracture conductivity is known more accurately.

Description

Citation